MarineBusiness-World.com Advertising Info Advertising Info

 
News Home Text Only News Festival of Sails Sydney Hbr Regatta Alinghi - Auction Boat Asia 2012
World Cruising Australian Cruising Boats for Sale FishingBoating-World Powerboat-World

 


Sail-World.com : Putting a boat away for the winter - E-10 gas

Putting a boat away for the winter - E-10 gas

'Does your boat have E-10 gas in the tank? To avoid any problems over the long winter lay-up period, BoatUS says the tank should be filled to near its capacity.'    BoatUS ©    Click Here to view large photo

Boaters and anglers will soon be putting away their boats for the season. But before they do, Boat Owners Association of The United States (BoatUS) has some tips learned from fuel industry insiders on how to store a boat with E-10 gasoline (containing 10% ethanol) over the winter.

The Octane issue:

Over long winter storage periods, E-10 gasoline loses octane at about the same rate as non-ethanol gasoline. So leaving the gas tank mostly empty - and then refilling in the spring in the hopes of 'refreshing' the fuel to regain any octane loss - is not necessary. However, a nearly empty gas tank introduces another problem: the strong possibility of phase separation.

Ethanol (an alcohol) attracts water. It also absorbs water - about 10 times more than regular gasoline. When ethanol can no longer absorb the water, it will 'phase separate' from the gasoline. Should phase separation occur, the (water soaked) ethanol will settle to the bottom of the tank, which is where the engine's fuel system pick-up is located.

The problem with leaving a tank mostly empty is that it increases the tank's 'lung capacity' to breath in moist air (water) through the vent. If the tank is mostly empty over the winter, there will also be less E-10 gas in the tank to absorb the moisture. This combination of more water and less absorption greatly increases the chances of phase separation. Adding fresh gasoline in the spring would not remedy the problem - the phase-separated ethanol would remain separated at the bottom of the tank.

The Water Separator issue:

Any moisture in a tank will be readily absorbed by the ethanol. E-10 can hold up to 1/2 percent of water by volume and up to that concentration the water molecules will dissolve in the gasoline forming a soluble mixture that will pass through a water separator and burn harmlessly in your engine.

The only time water will collect in a tank and not be absorbed is if phase separation has occurred, and by then it will be too late. A water separator is not a solution to the phase separation problem.

The Fuel Additive issue:

Fuel additives are good for many reasons and should be used when laying up a boat for winter, but no additive will stand up to a good-sized slug of water. And once too much water has entered the tank and the gas has begun to phase separate, no additive will return the fuel to its original state. The only solution to phase-separated gas is to have a professional drain the tank and start anew.

The best advice for storing E-10 in your boat's gas tank over winter:

Keep the tank nearly full. This greatly reduces the volume of moist air that can enter the tank via the fuel tank vent when temperatures fluctuate in the fall and spring. With any fuel, an antioxidant will help keep it fresh during lay-up. Finally, never plug up a fuel tank vent - it creates pressure that could cause dangerous leaks in the fuel system.

For more information including free downloadable winterizing checklists, go to www.BoatUS.com/winter




by Boat US

  

Click on the FB Like link to post this story to your FB wall

http://www.marinebusiness-world.com/index.cfm?nid=74476

2:32 PM Thu 9 Sep 2010 GMT



Click here for printer friendly version
Click here to send us feedback or comments about this story.


 
Our Advertisers are committed to our sport, please support them!
This site and its contents are © Copyright TetraMedia Pty. Ltd and/or the original author, photographer etc. All Rights Reserved.

Photographs are copyright by law. If you wish to use or buy a photograph you must contact the photographer directly (there is a hyperlink in most cases to their website, or do a Google search.) with your request.

Please do not contact Sail-World.com as we cannot give permission for use of other photographer’s images.

Only if the photographer named on the image is Sail-world.com, Powerboat-world.com or Marinebusiness-world.com Contact us .
Ph: +61 2 4977 2116 fax: +61 2 4977 2528 or complete our feedback form    Contact us .
   View our Privacy Policy.    [Go Home]     [  Banner Advertising Specification]    [Bot Archive ]

Customised news feeds -Marine Industry companies, Clubs and Associations have their own customised version of our Sail-World news feed on their website.
Look_here_to_see_examples